US grounds some Boeing MAX planes for safety checks after cabin emergency

US regulators on Saturday temporarily grounded 171 Boeing 737 MAX 9 jetliners for safety checks following a cabin panel blowout that forced a new Alaska Airlines jet carrying passengers to make an emergency landing, Report informs via Reuters.

A piece of fuselage tore off the left side of the jet as it climbed following takeoff from Portland, Oregon, en route to Ontario, California, on Friday, forcing pilots to turn back and land safely with all 171 passengers and six crew on board.

Several passengers suffered injuries. The plane had been in service for just eight weeks.

Late on Saturday, both Alaska Air and United Airlines said they would halt use of some MAX 9 planes they had resumed using that day after inspections they believed would answer the Federal Aviation Administration (FAA)'s concerns.

Alaska said it was in talks "to determine what, if any, further work is required before these aircraft are returned to service."

The FAA decision is well short of the global grounding of Boeing MAX jets almost five years ago after two crashes that killed nearly 350 people.

Still, it is a blow to Boeing as it tries to recover from back-to-back crises over safety and the pandemic under heavy debt.

The FAA did not rule out further action as a probe began into the apparent structural failure, which left a rectangular hole in an area of fuselage reserved for an optional extra door but which is deactivated on Alaska's aircraft.

The Boeing 737 MAX 9s fitted with a special door replacement "plug" cannot fly until they are inspected and repaired if necessary, the FAA said.

"The FAA is requiring immediate inspections of certain Boeing 737 MAX 9 planes before they can return to flight," FAA chief Mike Whitaker said.

Social media posts of the Alaska Airlines jet showed oxygen masks deployed and a portion of the aircraft's side wall missing.

A section of the fuselage reserved for the optional door had vanished, leaving a neat door-shaped gap. The seat next to the panel, which contained an ordinary window, had been unoccupied.

The fuselage for Boeing 737s is made by Kansas-based Spirit AeroSystems, which separated from Boeing in 2005. Spirit manufactured and installed the particular plug door that suffered the blowout, a source told Reuters on Saturday.

The MAX 9 represents about 220 of the 1,400 MAX jets delivered so far and most of them have the deactivated door, meaning they are potentially covered by the order.

Boeing said it supported the FAA decision.